Transport of blood samples with small drones

In a proof-of-concept study at Johns Hopkins, researchers have shown that results of common and routine blood tests are not affected by up to 40 minutes of travel on hobby-sized drones.

Pathologist Timothy Amukele, left, teamed with Robert Chalmers and other...
Pathologist Timothy Amukele, left, teamed with Robert Chalmers and other engineers to create a drone courier system that will transport blood to diagnostic laboratories.
Source: Johns Hopkins Medicine

The investigators say that’s promising news for the millions of people cared for in rural and economically impoverished areas that lack passable roads in developing nations because drones can give health care workers quick access to lab tests needed for diagnoses and treatments. Most tests on blood samples and other fluids are done by dedicated laboratories that can be scores of miles from remote clinics.

“Biological samples can be very sensitive and fragile,” says Timothy Kien Amukele, M.D., Ph.D., a pathologist at the Johns Hopkins University School of Medicine, and director of a laboratory collaboration between Johns Hopkins and Uganda’s Makerere University. That sensitivity makes even the pneumatic-tube systems used by many hospitals, for example, unsuitable for transporting blood for certain purposes.

Of particular concern related to the use of drones, Amukele notes, is the sudden acceleration that marks the launch of the vehicle and the jostling when the drone lands on its belly. “Such movements could have destroyed blood cells or prompted blood to coagulate and I thought all kinds of blood tests might be affected, but our study shows they weren’t, so that was cool,” he says.

For the study, which Amukele believes is the first rigorous examination of the impact of drone transport on biological samples, his team collected a total of six blood samples from each of 56 healthy adult volunteers at Johns Hopkins Hospital. The samples were then driven to a flight site an hour’s drive from the hospital on days when the temperature was in the 70s. There, half of the samples were packaged for flight, with a view to protecting them for the in-flight environment and preventing leakage. Those samples were then loaded into a hand-launched fixed-wing drone and flown around for periods of six to 38 minutes. Owing to Federal Aviation Administration rules, the flights were conducted in an unpopulated area, stayed below 100 meters (328 feet), and were in the line of sight of the certified pilot.

The other half of the samples were driven back from the drone flight field to The Johns Hopkins Hospital Core Laboratory, where they underwent the 33 most common laboratory tests that together account for around 80% of all such tests done. A few of the tests performed were for sodium, glucose, and red blood cell count.

Comparing lab results of the flown vs. non-flown blood of each volunteer, Amukele says “the flight really had no impact.”  Amukele and his team noted that one blood test — for total carbon dioxide (the so-called bicarbonate test) — did yield differing results for some of the flown vs. non-flown samples. Amukele says the team isn’t sure why, but that the reason could be because the blood sat around for up to eight hours before being tested. There were no consistent differences between flown vs. non-flown blood, Amukele says, and it’s unknown whether the out-of-range results were due to the time lag or because of the drone transport. “The ideal way to test that would be to fly the blood around immediately after drawing it, but neither the FAA nor Johns Hopkins would like drones flying around the hospital,” he said with a smile.

Given the successful proof-of-concept study results, Amukele says the likely next step is a pilot study in a location in Africa where health care clinics are sometimes 60 or more miles away from labs. “A drone could go 100 km in 40 minutes,” says Amukele. “They’re less expensive than motorcycles, are not subject to traffic delays, and the technology already exists for the drone to be programmed to ‘home’ to certain GPS coordinates, like a carrier pigeon.” Drones already have been tested as carriers of medicines to clinics in remote areas, but whether and how drones will be used in flights over populated areas will depend on laws and regulations.


Source: Johns Hopkins Medicine

24.08.2015

More on the subject:
Read all latest stories

Related articles

Photo

News • Neurological Disorders

Predicting the risk of post-treatment brain bleeding after stroke

In a study of stroke patients, investigators confirmed through MRI brain scans that there was an association between the extent of disruption to the brain's protective blood-brain barrier and the…

Photo

News • Philips and Banyan Biomarkers

Partnership for handheld blood test to detect and evaluate concussions

Royal Philips and Banyan Biomarkers, Inc. today announced that they have entered into a multi-year joint development agreement to develop and commercialize a new handheld blood test to detect and…

Photo

Sponsored • Hot topic II

News from Israel

CNOGA Medical Ltd. is a leading developer and manufacturer of innovative e-health ecosystems for non-invasive, pain-free bio-marker monitoring and cloud-based ecosystem technology. At MEDICA CNOGA…

Related products

Subscribe to Newsletter